Translational studies on a ready-to-use intramuscular injection of penethamate for bovine mastitis.

Bovine mastitis caused by bacterial infections of the mammary gland (udder) of dairy cows is a costly pathology for the dairy industry due to direct and indirect losses in production. Penethamate, a pro-drug of benzylpenicillin, is used by intramuscular injection (IM). The existing products are powders which must be reconstituted in water-for-injection and this presents difficulties in the field. Penethamate is too unstable to be formulated as an aqueous formulation but a chemically stable suspension formulation was possible in certain oils; however, some literature suggests that such formulations would have unacceptable prolonged release. The translational research proceeded iteratively from lab to the target species, rather than via laboratory animal trials. Pilot studies in cows suggested that some oily suspensions would give concentrations of benzylpenicillin, (in both blood and milk) comparable with those of the reconstituted product. A physicochemical screen and a low level in vitro-in vivo correlation (IVIVC) was cautiously used to guide selection of formulations for subsequent animal trials which have resulted in a lead formulation for good laboratory practices (GLP), good clinical practices (GCP) studies.

Susceptibility to antimicrobials of mastitis-causing Staphylococcus aureus, Streptococcus uberis and Str. dysgalactiae from New Zealand and the USA as assessed by the disk diffusion test.

OBJECTIVE: To compare the antimicrobial susceptibility patterns of three common mastitis pathogens (Staphylococcus aureus, Streptococcus uberis and Str. dysgalactiae) isolated from milk samples from New Zealand and the USA. METHODS: A total of 182 S. aureus, 126 Str. uberis and 89 Str. dysgalactiae isolates from New Zealand (107, 106 and 41, respectively) and the USA (75, 20 and 48, respectively) were assessed using the disk diffusion test. RESULTS: Susceptibility varied among the bacterial species. All isolates were susceptible to the amoxicillin-clavulanic acid combination. Resistance to lincomycin was most frequent (susceptibility of 8.6%) across all species. Non-susceptible (i.e. resistant or intermediate) isolates of S. aureus were identified for the three non-isoxazolyl penicillins (amoxicillin, ampicillin and penicillin: 20.6% and 36.0%) and lincomycin (99.9% and 94.6%) for NZ and the USA, respectively. Resistance to erythromycin (5.3%) and tetracyclines (6.7%) was detected only in isolates from the USA. There were differences in susceptibility between Str. uberis and Str. dysgalactiae; all streptococcal isolates demonstrated resistance to aminoglycosides (neomycin 52.4% and streptomycin 27.9%) and enrofloxacin (28%). Resistance of Str. dysgalactiae to tetracycline was almost 100.0% and to oxytetracycline 89.9%. CONCLUSION AND CLINICAL RELEVANCE: Most of the isolates tested were susceptible to most of the antimicrobials commonly used for treatment of bovine mastitis, with the exception of the lincosamides. Susceptibility to a selected class-representative antimicrobial and at the genus level should be interpreted with caution. Differences between NZ and the USA confirm the value of national surveys to determine the susceptibility patterns of mastitis pathogens.

An approach for identifiability of population pharmacokinetic-pharmacodynamic models.

Mathematical models are routinely used in clinical pharmacology to study the pharmacokinetic and pharmacodynamic properties of a drug in the body. Identifiability of these models is an important requirement for the success of these clinical studies. Identifiability is classified into two types, structural identifiability related to the structure of the mathematical model and deterministic identifiability which is related to the study design. There are existing approaches for assessment of structural identifiability of fixed-effects models, although their use appears uncommon in the literature. In this study, we develop an informal unified approach for simultaneous assessment of structural and deterministic identifiability for fixed and mixed-effects pharmacokinetic or pharmacokinetic-pharmacodynamic models. This approach uses an information theoretic framework. The method is applied both to simple examples to explore known identifiability properties and to a more complex example to illustrate its utility.CPT: Pharmacometrics & Systems Pharmacology (2013) 2, e49; doi:10.1038/psp.2013.25; advance online publication 19 June 2013.

Culture results from milk samples submitted to veterinary diagnostic laboratories from August 2003 to December 2006 in New Zealand.

AIMS: To determine the pattern of isolation of major mastitis-causing organisms isolated from milk samples submitted to five veterinary diagnostic laboratories in New Zealand. METHODS: The culture results of 25,288 milk samples that were collected from dairy cows throughout New Zealand from August 2003 to December 2006 and submitted to a group of veterinary diagnostic laboratories were assembled, reviewed and summarised. Logistic regression was used to analyse the effect of year, region (i.e. North vs South Island), and season on the probability of isolating the two most common organisms. RESULTS: The most commonly isolated mastitis causing organisms from all samples were: Streptococcus uberis (23.6%), Staphylococcus aureus (23.5%), coagulase-negative staphylococci (CNS; 7.2%), Strep. dysgalactiae (6.2%), Bacillus spp. (4.0%), and coliforms (3.7%). The percentage of samples with isolates of Strep. uberis or Staph. aureus was affected by island, year and season (p<0.001). For most of the year, except in late winter and early spring when Strep. uberis was much more common, the percentage of isolates of Strep. uberis and Staph. aureus were not apparently different despite the former being an environmental pathogen and the other a contagious one. CONCLUSION: The pattern of isolation of major mastitis-causing organisms, as determined from culture of milk samples submitted to diagnostic laboratories in New Zealand, has changed significantly over the last 40 years, with a substantial increase in the percentage of isolates that are Strep. uberis and a decrease in isolates of Strep. agalactiae. There is a clear seasonal pattern to the isolation of both Strep. uberis and Staph. aureus, particularly the former. CLINICAL RELEVANCE: Knowledge of the aetiological agents causing bovine mastitis on a farm is of value in determining the choice of treatment. This dataset shows that, although there is seasonal pattern to the isolation of mastitis-causing organisms in New Zealand, both Strep. uberis and Staph. aureus are isolated throughout the year, so bacteriology is of value in determining aetiology even in late winter/early spring.

Efficacy of a novel internal dry period teat sealant containing 0.5% chlorhexidine against experimental challenge with Streptococcus uberis in dairy cattle.

The incidence of clinical mastitis and infection status at calving was assessed in quarters treated with 1 of 2 internal teat sealants at the time of dry off. Two contralateral quarters per cow (n=63 cows) were treated with a sealant that contained 0.5% chlorhexidine; the other quarters were treated with a commercial teat sealant. Ten cows were untreated (controls). On d 2, 4, and 16 after dry off, cows were challenged with Streptococcus uberis S210 strain. Cows were examined daily for 34 d after drying off and cases of clinical mastitis were recorded. Milk samples were collected for culture from any quarters that developed clinical mastitis during the first 34 d after drying-off and from all quarters on d -5 and 0 relative to treatment and at the first and twentieth milking after calving. The incidence of clinical mastitis during the examination period was lower in treated quarters (n=7/252; 1.5%; lower incidence for those treated with chlorhexidine-containing teat sealant n=3/126; 1.2%) than in untreated quarters (n=13/40; 26.8%). The protection against intramammary infection after calving, adjusted for the effect of cow, was higher in quarters treated with the novel teat sealant (89/105; 15.2%; 95% CI=9.6-23.4) than in those treated with the commercial teat sealant (71/104; 31.7%; 95% CI=23.5-41.3) and untreated controls (6/28; 78.6%; 95% CI=59.8-90.0), respectively. Quarters treated with teat sealants were less likely to have an intramammary infection after calving and had a lower incidence of clinical mastitis during the early dry period than did untreated controls in this challenge study.

Polymeric nanoparticles as an oral delivery system for biocontrol agents for the brushtail possum (Trichosurus vulpecula).

AIM: To investigate polymeric nanoparticles as an oral delivery system for protein biocontrol agents for control of the brushtail possum, Trichosurus vulpecula. METHODS: Insulin-loaded poly(ethyl 2-cyanoacrylate) (PECA) nanoparticles were prepared using interfacial polymerisation, and characterised for size, zeta potential, and efficiency of encapsulation of insulin. In-vitro release of insulin-loaded PECA nanoparticles was quantified using reverse-phase high-pressure liquid chromatography (HPLC). The in-vivo pharmacokinetics of insulin in PECA nanoparticles was investigated following I/V administration, and when injected directly into the caecum alone or in conjunction with the permeation enhancer EDTA. Blood samples were collected at intervals from -5 to 180 minutes, and the concentration of insulin in plasma was quantified using a radioimmunoassay (RIA) validated for possum plasma. RESULTS: Poly(ethyl 2-cyanoacrylate) nanoparticles were produced with a uniform particle size of 200-300 nm, and the mean entrapment of insulin was 78%. In-vitro release of insulin from the PECA nanoparticles was controlled, although incomplete, and approximately 30% of the insulin remained entrapped. The bioavailability of insulin when administered in a PECA nanoparticulate formulation injected directly into the caecum was <1%, and was not increased by addition of the permeation enhancer. CONCLUSIONS: The nanoparticulate formulations investigated as part of this study resulted in low bioavailability of the peptide insulin in the brushtail possum.

Crosslinking of drug-alginate granules. Part 2. Effect of granule preparation and composition on granule properties.

Paracetamol-alginate (Keltone HVCR) (1:1) granules were prepared by a wet granulation process followed by crosslinking of dried granules in calcium chloride solution. The effect of shear (planetary (low), Brabender (high)), binder quantity (1:2, 1:1 water:powder) and drug particle size (PS 98, 275 microm) were studied using a factorial design. Supporting studies were carried out varying binder quantity and alginate grade (viscosity). In the pre-treated granules, drug entrapment was mainly influenced by drug PS, where the smaller particles showed better embedding. After crosslinking, drug particle size continued to be the most important factor influencing drug recovery. All factors influenced early stage release where high shear, high binder, small drug PS granules showed least release and the low shear, low binder and large drug PS granules showed greatest release. Some significant two-factor interactions were found. Granule consolidation (shown by SEM) and particle embedding increased with binder quantity and reduced as the alginate viscosity was increased. Crosslinking, as shown by Na and Ca contents was >90%. The impact of granule consolidation on drug entrapment and recovery was relatively small (<10%) when compared to its effect on early stage drug release (>60%) which may be important if these granule systems are to be used for taste improvement.

Enhancing absorption of fluorescein and LHRH across hindgut epithelia in a marsupial, the common brushtail possum Trichosurus vulpecula.

We have identified differences in transport properties of intestinal epithelia in the marsupial brushtail possum, compared to eutherian mammals. To determine whether differences in its permeability to hydrophilic compounds also occur, the absorption of sodium fluorescein and luteinizing hormone releasing hormone (LHRH) was assessed in vitro and the ability of chemical enhancers and a metabolic inhibitor to promote their absorption investigated. The apparent permeability of colonic and caecal tissues to fluorescein and LHRH and transepithelial resistance (Rt) in the absence or presence of ethylenediamine tetra-acetic acid (EDTA), sodium deoxycholic acid (SDA), dithiothreitol (DTT), polyacrylic acids (PAA), or the inhibitor bacitracin were determined. The effects of SDA and/or DTT on adherent mucus and the release of lactate dehydrogenase (LDH) were also assessed. In the absence of treatment, both tissues had comparable amounts of adherent mucus, Rt and low permeabilities to fluorescein and LHRH. All chemical enhancers increased fluorescein permeability, but SDA at concentrations >0.5 mM also induced LDH release. DTT alone and in combination with SDA reduced the amount of adherent mucus. Bacitracin inhibited LHRH metabolism and increased LHRH permeability. These data indicate that the possum hindgut epithelium represents a significant barrier to the uptake of hydrophilic compounds, similar to that in eutherians.

W/O microemulsions for ocular delivery: evaluation of ocular irritation and precorneal retention.

Water-in-oil microemulsions (w/o ME) capable of undergoing a phase-transition to lamellar liquid crystals (LC) or bicontinuous ME upon aqueous dilution were formulated using Crodamol EO, Crill 1 and Crillet 4, an alkanol or alkanediol as cosurfactant and water. The hypothesis that phase-transition of ME to LC may be induced by tears and serve to prolong precorneal retention was tested. The ocular irritation potential of components and formulations was assessed using a modified hen's egg chorioallantoic membrane test (HET-CAM) and the preocular retention of selected formulations was investigated in rabbit eye using gamma scintigraphy. Results showed that Crill 1, Crillet 4 and Crodamol EO were non-irritant. However, all other cosurfactants investigated were irritant and their irritation was dependent on their carbon chain length. A w/o ME formulated without cosurfactant showed a protective effect when a strong irritant (0.1 M NaOH) was used as the aqueous phase. Precorneal clearance studies revealed that the retention of colloidal and coarse dispersed systems was significantly greater than an aqueous solution with no significant difference between ME systems (containing 5% and 10% water) as well as o/w emulsion containing 85% water. Conversely, a LC system formulated without cosurfactant displayed a significantly greater retention compared to other formulations.

Gastrointestinal transit in the common brushtail possum measured by gamma scintigraphy.

This paper reports an example of the application of pharmaceutical technology to wildlife management, specifically the design of an oral delivery system for the common brushtail possum in New Zealand. Designing an oral delivery system requires a knowledge of the time taken for particulates to reach target sites within the gastrointestinal tract (GIT). The transit time for fluid and indigestible particles of two different size ranges was determined in the common brushtail possum (Trichosurus vulpecula). Technetium-labelled (99mTc) anion exchange resin particles (75-125 or 500-700 microm diameter) or solution (99mTc-labelled diethylenetriamine pentaacetic acid, 99mTc-DTPA) was administered orally. At predetermined times after dosing (3, 6, 12, 24 or 32 h), the distribution of radioactivity throughout excised gastrointestinal tracts was determined by gamma scintigraphy. The transit profile was similar for the three formulations investigated. Unlike other closely related hindgut fermenting marsupials, there was no evidence to support the presence of a colonic separating mechanism in the common brushtail possum. Gastrointestinal transit was independent of body mass, gender and time of day that the dose is given. To target the hindgut for oral delivery of protein and peptide biocontrol agents, the formulation would need to protect the bioactive for approximately 12 h prior to release.

Cross-linking of dried paracetamol alginate granules Part 1. The effect of the cross-linking process variables.

This paper reports on the cross-linking of dried (<5% moisture) paracetamol alginate granules with calcium chloride solutions. The effect of calcium concentration, temperature of the treatment solution, stirring speed and time used during cross-linking of granules on water uptake by the granules during cross-linking and physical properties of the cross-linked and dried granules were studied. A full factorial study of these factors each at two levels was used (CaCl2.2H2O: 20, 100 mg/ml; temperature: 25, 45 degrees C; stirrer speed: 25, 240 rpm; time: 1.5 and 5.5 min) to treat dried stock granules (size: 0.8-1.0 mm) containing the model drug paracetamol and sodium alginate powder (1:1) which were prepared using conventional aqueous granulation under low shear. In addition to SEM and photomicrography, the physical properties studied were water uptake during cross-linking, yield, aggregation behaviour, moisture content, drug content, early stage drug release [over 10 s (R10) and the next 50 s (R50)] and calcium and sodium content of the unwashed cross-linked granules. Dry granules were successfully cross-linked. The treatment factors significantly affected most of the response variables. The variables most affected were water uptake (78-254%), drug entrapment (58-86%), early release (R10: 1.2-6.4% and R50: 3.0-12.2%), granule aggregation (0-70%), calcium (6.02-12.4%) and sodium content (1.2-6.44%). SEM photographs suggest that low calcium treated granules were less porous in nature compared to high calcium treated granules. Low shear drug alginate granules can be cross-linked in dried state. The properties of the cross-linked granules can be modified by altering the treatment process.

An in situ single-pass perfusion model for assessing absorption across the intestinal mucosa of the brushtail possum.

AIM: To develop an in situ animal model for assessing absorption of molecules across the intestinal mucosa of possums. METHODS: A surgical preparation was used to perfuse known concentrations of reference compounds (fluorescein and luteinising hormone-releasing hormone; LHRH) through measured sections of selected regions (jejunum, caecum, proximal colon) of the intestinal tract of 19 possums, over a 2-h period. Plasma concentrations of the compounds, which were perfused either with or without co-administration of a permeation enhancer (sodium deoxycholic acid; SDA), were determined in the perfusion effluent, peripheral and in some instances in the pre-hepatic circulation by spectrofluorometry (fluorescein) or radioimmunoassay (LHRH). Pharmacokinetic parameters of both compounds in the possum were determined over a period of up to 4 h in a further 30 animals (fluorescein, n = 6; LHRH n = 24), from their plasma profiles following intravenous (I/V) administration of a bolus dose. RESULTS: In animals perfused with 25 mg/ml fluorescein (Perfusion Experiment (PE) 1), the mean plasma concentration was 2.8 (SE 0.12) microg/ml in post-hepatic blood samples. When possums were perfused with 2.5 mg/ml fluorescein and 7 microg/ml LHRH (PE 2), mean plasma concentrations were 0.3 (SE 0.01) and 7.8 (SE 1.64) microg/ml fluorescein and 0.1 (SE 0.02) and 6.3 (SE 0.45) ng/ml LHRH, in the absence and presence of permeation enhancer, respectively. There was a poor correlation between pre-hepatic and post-hepatic concentrations. CONCLUSIONS: The single-pass in situ perfusion technique provided a useful model for investigating basic information on the absorption of biocontrol agents across the intestinal tract of possums, but had limitations that must be recognised.

Design and evaluation of an early stage drug release apparatus.

This paper describes the design and evaluation of an early stage drug release apparatus (ERA) to determine drug release from pellets at times less than 1 min. The apparatus comprises a stirred sample chamber in which the sample is retained by a BS150 mesh screen (0.106 mm), and a series of jacketed cups containing the medium (80 ml) which are raised and lowered in turn over the fixed sample chamber for specified periods. Three types of early release studies were used: single 60s study (single cup), 10s followed by 50s (two cups) and 10, 20, 30...60s multiple changeover differential release (six cups). The effects of stirrer speed, stirrer position and multiple changeover on drug release from standard paracetamol-alginate pellets were investigated. Drug release rates from non-disintegrating pellets were reproducibly determined. The three types of early release study schemes yielded reproducible drug release data over sampling times less than 1 min. Stirrer speed, and depth, and changeover motion of release cups affected drug release but yielded reproducible results. Release from the standard pellets used to study the apparatus took 3 days to stabilize and remained stable thereafter. The apparatus can be used for screening of pellet formulations of sparingly soluble drugs during their developmental stage and regular quality assurance studies of pellets (>150 mesh size). Along with early release studies of pellets, it could be easily modified to study other types of formulations and for automation.

The metabolic barrier of the lower intestinal tract of salmon to the oral delivery of protein and peptide drugs.

Oral delivery of peptide and protein drugs has potential advantages for the aquaculture industry. The bioavailability of proteins and peptides from the intestinal tract is very low. This can be attributed in part to the proteolytic activities of the intestine. Bovine serum albumin (BSA), human (hLHRH) and salmon (sLHRH) luteinizing-hormone releasing hormones were used to evaluate the proteolytic activity of anterior, middle and posterior sections of the Quinnat salmon (Oncorhynchus tshawytscha) intestinal tract. The lumenal proteolytic activities of the posterior intestinal section towards BSA were approximately half that of the anterior and middle sections. The half-lives of the LHRH analogues in the posterior were twofold longer than for the anterior and middle sections. Proteolytic activity of the posterior mucosal homogenates towards BSA was fourfold higher than the middle mucosal homogenates. LHRH analogues were hydrolysed by the posterior mucosal homogenate, whereas in the middle mucosal homogenate they were stable. Soybean trypsin inhibitor was shown to be the most effective inhibitor of lumenal proteolytic activity towards LHRH analogues. Sodium deoxycholate, EDTA and bestatin significantly inhibited the posterior mucosal hydrolytic activity towards the LHRH analogues. The posterior intestine of salmon is the most favourable site for the delivery of BSA and LHRH analogues with respect to the lumen, however the higher proteolytic activity of the posterior mucosa has to be overcome.

Inhibition of proteolysis in luminal extracts from the intestine of the brushtail possum.

The proteolytic activity of luminal extracts from five regions (duodenum, jejunum, ileum, caecum and colon) of the brushtail possum intestine towards bovine serum albumin (BSA) and human luteinizing hormone releasing hormone (LHRH) was investigated. There were no significant differences in degradation rates between fresh and previously frozen extracts from any region of the possum intestine. The inhibition of degradation of BSA by luminal extracts from two regions (jejunum and ileum) and of LHRH from four regions (jejunum, ileum, caecum and colon) was evaluated. Soybean trypsin-chymotrypsin inhibitor (SBTI), sodium deoxycholate, Carbopol 934P, bacitracin and bestatin significantly inhibited the degradation of both LHRH and BSA (P < 0.05). SBTI almost totally inhibited the proteolysis of BSA and the peptidolysis of LHRH in extracts from the small intestine. This finding suggests that serine proteases such as chymotrypsin are responsible for the protein and peptide degradation in luminal extracts. It is concluded that including serine protease inhibitors in a formulation may enhance oral delivery of bioactive peptides and proteins to possums.

Enzymatic degradation of luteinizing hormone releasing hormone (LHRH) by mucosal homogenates from the intestine of the common brushtail possum (Trichosurus vulpecula).

The peptidolytic activity of fresh and frozen mucosal homogenates from five regions (duodenum, jejunum, ileum, caecum and colon) of possum intestine from Trichosurus vulpecula towards human Luteinizing Hormone Releasing Hormone (LHRH) was investigated. The rank of order of specific peptidolytic activity of the mucosal homogenates was jejunum > ileum > caecum> duodenum = colon, with a 3 to 4 fold difference between the least and the most active segment in both frozen and fresh samples. The formation of peptides LHRH (1-3), LHRH (1-4) and LHRH (1-5) suggest endopepetidase-24.18, endopeptidase-24.15 and angiotensin converting enzyme (ACE) might be responsible for the peptide degradation in mucosal homogenates. The inhibition of LHRH degradation by mucosal homogenates was evaluated in four regions (jejunum, ileum, caecum and colon) of possum intestine. Ethylenediaminetetraacetic acid (EDTA, 5 mM), sodium deoxycholate (SDA, 10 mM) and bacitracin (3.5 or 9 mM) inhibited the degradation of LHRH in mucosal homogenates from small intestine and hindgut. However, the serine protease inhibitor, soybean trypsin-chymotrypsin inhibitor (SBTI), did not prevent degradation of LHRH. It is concluded that combining peptides with inhibitors may enhance oral delivery of bioactive peptides or proteins to possums.

Protein and peptide degradation in the intestine of the common brushtail possum (Trichosurus vulpecula).

A protein (bovine serum albumin: BSA) and a peptide (luteinizing hormone releasing hormone: LHRH) were used to evaluate proteolytic activity in the intestine of common brushtail possums (Marsupiala, Trichosurus vulpecula). Luminal and mucosal extracts were isolated from the duodenum, jejunum, ileum, caecum, proximal colon and distal colon, their protein content assessed and specific activities in metabolising LHRH and BSA determined in vitro. The degradation of LHRH by luminal extracts was compared with that by the pancreatic enzymes, chymotrypsin, trypsin, and elastase. The protein concentration (microg x mg-1) of mucosal extract in the duodenum was higher ( P<0.05) than in the proximal colon, but that of luminal extracts did not differ significantly between regions. Proteolytic activity of luminal extracts was greater ( P<0.01) in the jejunum and ileum than in the hindgut. In the small intestine, proteolytic activity of luminal enzymes far exceeded that of mucosal enzymes ( P<0.05). All three pancreatic enzymes hydrolysed LHRH, but chymotrypsin had the greatest activity. This study has demonstrated that, in possums, proteolysis occurs primarily in the small intestine through luminal enzymes, with chymotrypsin playing a major role. The possum hindgut contributes little to the metabolism of peptides and proteins, identifying it as a potential site to target for their absorption following oral delivery.

Effects of formulation variables on characteristics of poly (ethylcyanoacrylate) nanocapsules prepared from w/o microemulsions.

The effect of several formulation variables on some of the physico-chemical characteristics of poly (ethyl cyanoacrylate) (PECA) nanocapsules prepared by the interfacial polymerisation of biocompatible water-in-oil microemulsions was investigated. In all cases, yields were high (>90%) and the polydispersity in size of nanocapsules was narrow. The molecular weight of the nanocapsules formed was influenced by the pH of the aqueous component of the microemulsion, increasing with increasing pH. The size of the nanocapsules formed (ranging from around 130 to 180 nm) was a function of the ratio of the mass of monomer used to the water weight fraction of the microemulsion, increasing as this ratio was increased. This is due to the formation of a thicker polymer wall resulting from the increased mass of monomer available per unit interfacial area as this ratio is increased. The rate of release of insulin from nanocapsules was also influenced by this ratio, in agreement with its effect on wall thickness. This study demonstrates that many pharmaceutically relevant physico-chemical properties of poly (alkyl cyanoacrylate) (PACA) nanocapsules prepared by interfacial polymerisation of microemulsions can readily be manipulated by changing either the pH of the aqueous component, the water weight fraction of the microemulsion or the mass of monomer used for polymerisation.

Determination of polymorphic forms of ranitidine-HCl by DRIFTS and XRPD.

The identification, characterization and quantification of crystal forms are becoming increasingly important within the pharmaceutical industry. A combination of different physical analytical techniques is usually necessary for this task. In this work solid-state techniques, diffuse reflectance infrared Fourier transform spectroscopy (DRIFTS) and X-ray powder diffractometry (XRPD) were combined to analyze polymorphic purity of crystalline ranitidine-HCl, an antiulcer drug, H2 receptor antagonists. A series of 12 different mixtures of Form 1 and 2 was prepared by geometric mixing and their DRIFT spectra and XRD powder patterns were obtained and analyzed, either alone or combined together, using Artificial Neural Networks (ANNs). A standard feed-forward network, with back-propagation rule and with multi layer perceptron architecture (MPL) was chosen. A working range of 1.0-100% (w/w) of crystal Form 2 in Form 1 was established with a minimum quantifiable level (MQL) of 5.2% and limit of detection of 1.5% (w/w). The results demonstrate that DRIFTS combined with XRPD may be successfully used to distinguish between the ranitidine-HCl polymorphs and to quantify the composition of binary mixtures of the two.

Characterizing colloidal structures of pseudoternary phase diagrams formed by oil/water/amphiphile systems.

Two pseudoternary phase diagrams were constructed using ethyl oleate, water, and a surfactant blend containing poly (oxyethylene 20) sorbitan monooleate and sorbitan monolaurate with or without the cosurfactant 1-butanol. Two colloidal regions were identified in the cosurfactant-free phase diagram; a microemulsion (ME) and a region containing lamellar liquid crystals (LC). The addition of 1-butanol increased the area in which systems formed microemulsions and eliminated the formation of any liquid crystalline phases. Samples that form the colloidal regions of both systems were investigated by freeze-fracture transmission electron microscopy and by viscosity and conductivity measurements. The three techniques were compared and evaluated as characterisation tools for such colloidal systems and also to identify transitions between the colloidal systems formed. A droplet ME was present at a low water volume fraction (phi w) in both systems (phi w < 0.15) as revealed by electron microscopy. At higher phi w values, LC structures were observed in micrographs of samples taken from the cosurfactant-free system while the structure of samples from the cosurfactant-containing system was that of a bicontinuous ME. The viscosity of both systems increased with increasing phi w to 0.15 and flow was Newtonian. However, formation of LC in the cosurfactant-free system resulted in a dramatic increase in viscosity that was dependent on phi w and a change to pseudoplastic flow. In contrast, the viscosity of the bicontinuous ME was independent of phi w. Three different methods were used to estimate the percolation threshold from the conductivity data for the cosurfactant-containing system. The use of nonlinear curve fitting was found to be most useful yielding a value close to 0.15 for the phi w.